ARTICLENo Access

Formulating propranolol as an amorphous melt affords reduced skin irritation potential for transdermal drug delivery

Kazuhiro Aoyagi

Department of Chemical Engineering, University of California, Santa Barbara, CA 93106, USA.

Development Department, Medical Division, Nitto Denko Corporation, Osaki, Miyagi 989-6493, Japan.

K.A. and M.Z. contributed equally and are co-first authors.

Search for more papers by this author

Michael Zakrewsky

Department of Chemical Engineering, University of California, Santa Barbara, CA 93106, USA.

Center for Bioengineering, University of California, Santa Barbara, CA 93106, USA.

K.A. and M.Z. contributed equally and are co-first authors.

Search for more papers by this author

, and

Samir Mitragotri

Department of Chemical Engineering, University of California, Santa Barbara, CA 93106, USA.

Center for Bioengineering, University of California, Santa Barbara, CA 93106, USA.

E-mail Address: [email protected]

Search for more papers by this author

https://doi.org/10.1142/S2339547815500107Cited by:2 (Source: Crossref)

View article

Abstract

Oral propranolol is commonly the first-line treatment of infantile hemangioma. However, oral delivery of propranolol is limited by systemic side effects, particularly in infants. Topical application may be a more patient friendly alternative while concurrently affording targeted delivery to the site of the skin lesion. Unfortunately, dose-dependent skin irritation is typically observed when propranolol is applied topically. Of additional concern, irritation is often exacerbated by organic solvents required to formulate propranolol. To address these concerns, we present novel formulations of propranolol as amorphous melts. Propranolol melts were successfully synthesized, and their physicochemical properties were tuned suitably for transdermal delivery using dialkyl sulfosuccinates as the counter species. Melts used in this study possessed the ability to penetrate skin when applied neat, without the need of any addition of solvent. Moreover, skin irritation potential of the lead melt was reduced compared to that of the propranolol free base (PFB). This reduction may be due to association of propranolol with the counter species in amorphous melts. The results presented here suggest amorphous melt formulations may open up the possibility to topically deliver drugs that traditionally elicit skin irritation.

References

1. Bruckner, A.L. & Frieden, I.J. Hemangiomas of infancy. J. Am. Acad. Dermatol. 48, 477–493 (2003). Crossref, Google Scholar
2. Drolet, B.A. et al. Initiation and use of propranolol for infantile hemangioma: Report of a consensus conference. Pediatrics 131, 128–140 (2013). Crossref, Google Scholar
3. Holmes, W.J., Mishra, A., Gorst, C. & Liew, S.H. Propranolol as first-line treatment for rapidly proliferating infantile haemangiomas. J. Plast. Reconstr. Aesthet. Surg. 64, 445–451 (2011). Crossref, Google Scholar
4. Prausnitz, M.R. & Langer, R. Transdermal drug delivery. Nat. Biotechnol. 26, 1261–1268 (2008). Crossref, Google Scholar
5. Prausnitz, M.R., Mitragotri, S. & Langer, R. Current status and future potential of transdermal drug delivery. Nat. Rev. Drug Discov. 3, 115–124 (2004). Crossref, Google Scholar
6. Brown, M.B., Martin, G.P., Jones, S.A. & Akomeah, F.K. Dermal and transdermal drug delivery systems: Current and future prospects. Drug Deliv. 13, 175–187 (2006). Crossref, Google Scholar
7. Hogan, D.J. & Maibach, H.I. Adverse dermatologic reactions to transdermal drug delivery systems. J. Am. Acad. Dermatol 22, 811–814 (1990). Crossref, Google Scholar
8. Murphy, M. & Carmichael, A.J. Transdermal drug delivery systems and skin sensitivity reactions incidence and management. Am. J. Clin. Dermatol. 1, 361–368 (2000). Crossref, Google Scholar
9. Jordan, W.P., Atkinson, L.E. & Lai, C. Comparison of the skin irritation potential of two testosterone transdermal systems: An investigational system and a marketed product. Clin. Ther. 20, 80–87 (1998). Crossref, Google Scholar
10. Toole, J. et al. Evaluation of irritation and sensitisation of two 50 ug/day oestrogen patches. Maturitas 43, 257–263 (2002). Crossref, Google Scholar
11. Wester, R.C. et al. Controlled release of benzoyl peroxide from a porous microsphere polymeric system can reduce topical irritancy. J. Am. Acad. Dermatol. 24, 720–726 (1991). Crossref, Google Scholar
12. Hori, M., Satoh, S., Maibach, H.I. & Guy, R.H. Enhancement of propranolol hydrochloride and diazepam skin absorption in vitro: Effect of enhancer lipophilicity. J. Pharm. Sci. 80, 32–35 (1991). Crossref, Google Scholar
13. Thacharodi, D. & Rao, K. Development and in vitro evaluation of chitosan-based transdermal drug delivery systems for the controlled delivery of propranolol hydrochloride. Biomaterials 16, 145–148 (1995). Crossref, Google Scholar
14. Amnuaikit, C., Ikeuchi, I., Ogawara, K., Higaki, K. & Kimura, T. Skin permeation of propranolol from polymeric film containing terpene enhancers for transdermal use. Int. J. Pharm. 289, 167–178 (2005). Crossref, Google Scholar
15. Krishna, R. & Pandit, J. Transdermal delivery of propranolol. Drug Dev. Ind. Pharm. 20, 2459–2465 (1994). Crossref, Google Scholar
16. Kobayashi, I. et al. Skin toxicity of propranolol in guinea pigs. J. Toxicol. Sci. 24, 103–112 (1999). Crossref, Google Scholar
17. Patel, D.C. & Ebert, C.D. Method for reducing skin irritation associated with drug/penetration enhancer compositions. United States Patent No. 4,855,294 patent 4855294 (1989). Google Scholar
18. Zakrewsky, M. et al. Ionic liquids as a class of materials for transdermal delivery and pathogen neutralization. Proc. Natl. Acad. Sci. USA 111, 13313–13318 (2014). Crossref, Google Scholar
19. Zhang, S., Sun, N., He, X., Lu, X. & Zhang, X. Physical properties of ionic liquids: Database and evaluation. J. Phys. Chem. Ref. Data 35, 1475–1517 (2006). Crossref, Google Scholar
20. Moran, P.D., Bowmaker, G.A., Cooney, R.P., Bartlett, J.R. & Woolfrey, J.L. Vibrational spectra of metal salts of bis(2-ethylhexyl)sulfosuccinate (AOT). J. Mater. Chem. 5, 295–302 (1995). Crossref, Google Scholar
21. Farooqi, Z.H. & Aboul-Enein, H.Y. IR and UV/visible spectra of propranolol and some fluorinated derivatives: Comparison of experimental and calculated values. Biospectroscopy 2, 131–141 (1996). Crossref, Google Scholar
22. Crowley, K.J., Forbes, R.T., York, P., Nyqvist, H. & Camber, O. Oleate salt formation and mesomorphic behavior in the propranolol oleic acid binary system. J. Pharm. Sci. 88, 586–591 (1999). Crossref, Google Scholar
23. Lin, Z. et al. Real-time endpoint monitoring and determination for a pharmaceutical salt formation process with in-line FT-IR spectroscopy. J. Pharm. Biomed. Anal. 41, 99–104 (2006). Crossref, Google Scholar
24. Hough, W.L. et al. The third evolution of ionic liquids: Active pharmaceutical ingredients. N. J. Chem. 31, 1429 (2007). Crossref, Google Scholar
25. Cojocaru, O.A. et al. Prodrug ionic liquids: Functionalizing neutral active pharmaceutical ingredients to take advantage of the ionic liquid form. MedChemComm. 4, 559–563 (2013). Crossref, Google Scholar
26. Neau, S.H., Shinwari, M.K. & Hellmuth, E.W. Melting-point phase-diagrams of free-base and hydrochloride salts of bevantolol, pindolol and propranolol. Int. J. Pharm. 99, 303–310 (1993). Crossref, Google Scholar
27. Britto, M.M., Cass, Q.B., Montanari, C.A. & Aboul-Enein, H.Y. Determination of partition coefficients for several propranolol analogues by reversed phase high performance liquid chromatography. J. Liq. Chromatogr. Relat. Technol. 22, 2139–2149 (1999). Crossref, Google Scholar
28. Mohsen-Nia, M., Ebrahimabadi, A.H. & Niknahad, B. Partition coefficient n-octanol/water of propranolol and atenolol at different temperatures: Experimental and theoretical studies. J. Chem. Thermodyn. 54, 393–397 (2012). Crossref, Google Scholar
29. Welss, T., Basketter, D.A. & Schroder, K.R. In vitro skin irritation: Facts and future. State of the art review of mechanisms and models. Toxicol. In Vitro 18, 231–243 (2004). Crossref, Google Scholar
30. Perkins, M.A., Osborne, R., Rana, F.R., Ghassemi, A. & Robinson, M.K. Comparison of in vitro and in vivo human skin responses to consumer products and ingredients with a range of irritancy potential. Toxicol. Sci. 48, 218–229 (1999). Crossref, Google Scholar
31. Ranke, J. et al. Biological effects of imidazolium ionic liquids with varying chain lengths in acute Vibrio fischeri and WST-1 cell viability assays. Ecotoxicol. Environ. Safety 58, 396–404 (2004). Crossref, Google Scholar
32. Bernot, R.J., Brueseke, M.A., Evans, White, M.A. & Lamberti, G.A. Acute and chronic toxicity of imidazolium-based ionic liquids on Daphnia magna. Environ. Toxicol. Chem. 24, 87–92 (2005). Crossref, Google Scholar
33. Stolte, S. et al. Anion effects on the cytotoxicity of ionic liquids. Green Chem. 8, 621–629 (2006). Crossref, Google Scholar
34. Stolte, S. et al. Effects of different head groups and functionalised side chains on the aquatic toxicity of ionic liquids. Green Chem. 9, 1170–1179 (2007). Crossref, Google Scholar
35. Bronaugh, R.L., Stewart, R.F. & Congdon, E.R. Methods for in vitro percutaneous absorption studies II. Animal models for human skin. Toxicol. Appl. Pharmacol. 62, 481–488 (1982). Crossref, Google Scholar
36. Shekaari, H., Mousavi, S.S. & Mansoori, Y. Thermophysical properties of ionic liquid, 1-pentyl-3-methylimidazolium chloride in water at different temperatures. Int. J. Thermophys. 30, 499–514 (2009). Crossref, Google Scholar
37. Pine, M., Favrot, L., Smith, S., McDonald, K. & Chidsey, C.A. Correlation of plasma propranolol concentration with therapeutic response in patients with angina pectoris. Circulation 52, 886–893 (1975). Crossref, Google Scholar
38. Danon, D., Goldstein, L., Marikovsky, Y. & Skutelsky, E. Use of cationized ferritin as a label of negative charges on cell surfaces. J. Ultrastruct. Res. 38, 500–510 (1972). Crossref, Google Scholar
39. Kobayashi, I. et al. Relationship between the skin permeation movement of propranolol and skin inflammatory reactions. Biol. Pharm. Bull. 21, 938–944 (1998). Crossref, Google Scholar
40. Karande, P., Jain, A. & Mitragotri, S. Discovery of transdermal penetration enhancers by high-throughput screening. Nat. Biotechnol. 22, 192–197 (2004). Crossref, Google Scholar
41. Samiei, N., Shafaati, A., Zarghi, A., Moghimi, H.R. & Foroutan, S.M. Enhancement and in vitro evaluation of amifostine permeation through artificial membrane (PAMPA) via ion pairing approach and mechanistic selection of its optimal counter ion. Eur. J. Pharm. Sci. 51, 218–223 (2014). Crossref, Google Scholar
42. Aucamp, M., Odendaal, R., Liebenberg, W. & Hamman, J. Amorphous azithromycin with improved aqueous solubility and intestinal membrane permeability. Drug Dev. Ind. Pharm. 41, 1100–1108 (2015). Crossref, Google Scholar
43. Balk, A. et al. Ionic liquid versus prodrug strategy to address formulation challenges. Pharm. Res. 32, 2154–2167 (2015). Crossref, Google Scholar
44. Wang, H. et al. Simultaneous membrane transport of two active pharmaceutical ingredients by charge assisted hydrogen bond complex formation. Chem. Sci. 5, 3449–3456 (2014). Crossref, Google Scholar
45. Stott, P.W., Williams, A.C. & Barry, B.W. Mechanistic study into the enhanced transdermal permeation of a model β-blocker, propranolol, by fatty acids: A melting point depression effect. Int. J. Pharm. 219, 161–176 (2001). Crossref, Google Scholar
46. Stott, P.W., Williams, A.C. & Barry, B.W. Transdermal delivery from eutectic systems: Enhanced permeation of a model drug, ibuprofen. J. Control. Rel. 50, 297–308 (1998). Crossref, Google Scholar
47. Stoimenovski, J. & MacFarlane, D.R. Enhanced membrane transport of pharmaceutically active protic ionic liquids. Chem. Commun. 47, 11429–11431 (2011). Crossref, Google Scholar
48. Stoimenovski, J., Dean, P.M., Izgorodina, E.I. & MacFarlane, D.R. Protic pharmaceutical ionic liquids and solids: Aspects of protonics. Faraday Discuss. 154, 335–352 (2012). Crossref, Google Scholar
49. Kelley, S.P. et al. Understanding the effects of ionicity in salts, solvates, co-crystals, ionic co-crystals, and ionic liquids, rather than nomenclature, is critical to understanding their behavior. Cryst. Growth Des. 13, 965–975 (2013). Crossref, Google Scholar
50. Bica, K., Shamshina, J., Hough, W.L., MacFarlane, D.R. & Rogers, R.D. Liquid forms of pharmaceutical co-crystals: Exploring the boundaries of salt formation. Chem. Commun. 47, 2267–2269 (2011). Crossref, Google Scholar
51. Moreira, D.N. et al. Brønsted acid–base pairs of drugs as dual ionic liquids: NMR ionicity studies. Tetrahedron 71, 676–685 (2015). Crossref, Google Scholar
52. Zhang, X. et al. Effect of small amount of water on CO₂ bubble behavior in ionic liquid systems. Ind. Eng. Chem. Res. 53, 428–439 (2014). Crossref, Google Scholar
53. Patinha, D.J.S. et al. The role of water in cholinium carboxylate ionic liquid’s aqueous solutions. J. Chem. Thermodyn. 84, 93–100 (2015). Crossref, Google Scholar
54. Haberler, M. & Steinhauser, O. On the influence of hydrated ionic liquids on the dynamical structure of model proteins: A computational study. Phys. Chem. Chem. Phys. 13, 17994–18004 (2011). Crossref, Google Scholar
55. Cojocaru, O.A., Kelley, S.P., Gurau, G. & Rogers, R.D. Procainium acetate versus procainium acetate dihydrate: Irreversible crystallization of a room-temperature active pharmaceutical-ingredient ionic liquid upon hydration. Cryst. Growth Des. 13, 3290–3293 (2013). Crossref, Google Scholar
56. Troncoso, J., Cerdeirina, C.A., Sanmamed, Y.A., Romani, L. & Rebelo, L.P.N. Thermodynamic properties of imidazolium-based ionic liquids: Densities, heat capacities, and enthalpies of fusion of bmim PF6 and bmim NTf2. J. Chem. Eng. Data 51, 1856–1859 (2006). Crossref, Google Scholar
57. ThermoFisher Scientific. Instructions of Human IL-1α ELISA Kit. Retrieved from https://www.thermofisher.com/order/catalog/product/EH2IL1A (2014). Google Scholar